Out of Print

Out of Print

Items 51 to 73 of 73 total

per page
Page:
  1. 1
  2. 2

List  Grid 

Set Descending Direction
  1. ATSG V.W. 01M Technicians Diagnostic Guide Mini CD

    V.W. 01M Technicians Diagnostic Guide Mini CD

    $35.00
    This manual covers Principles of Operation, Complete hydraulic circuit diagrams, Valve Body Mapping (passage identification for the valve body and all spacer plates). It also includes a complete exploded view of the valve body and identification of all valves and springs. Now includes 1998-up supplement pack. Learn More
  2. ATSG VW 09G / AUDI TF60SN TG Mini CD

    VW 09G / AUDI TF60SN TG Mini CD

    $35.00
    This manual provides a component application chart, clutch tap identification, exploded views of the valve body, extensive solenoid information, clutch pack configurations, case passage identification, complete hydraulic schematics, bulletins, updates, VAG code and OBD2 code identification on mini CD. Learn More
  3. ATSG U150/U250-E TG Mini CD

    U150/U250-E TG Mini CD

    $35.00
    Starting at the beginning of production for the 2002 model year for Lexus and 2004 for Toyota, a spin-off of the U140/U240 Four speed transaxle, designated as the U150/U250 series was born. This transmission is classified as a 5 speed transmission, although it has 6 ratio's possible in the Drive position. The U150/250 is very similar to it's smaller brother, the U140, and actually uses some of the same parts.
    This Transaxles shift points, and shift feel are electronically controlled by a Powertrain Control Module. This is accomplished by the PCM monitoring engine load and adjusting solenoid duty cycle to match pressure rise and shift feel. The PCM also monitors the turbine and output speed sensors to calculate gear ratio and the Transmission Range Sensor for gear selection.
    This Technicians guide will provide theory of operation starting with a component application, continuing on thru solenoid function both mechanically and hydraulically. The manual will also provide passage identification in the Mapping section, along with full color hydraulic schematics for all ranges. Refer to the index of Figures listed on the following page for the component or information desired On mini CD>. Learn More
  4. ATSG F5A51 Mini CD

    F5A51 Mini CD

    $40.00
    Mini CD for the F5A51 a five speed, Front Wheel Drive transaxle, with fully electronic controls for the upshifts and downshifts, with 5th gear being overdrive. The individual gear ratios are achieved through three planetary gear sets. The components of the planetary gear sets are driven or held by means of four multi-plate drive clutch packs, two multi-plate brake clutch packs, one reduction brake band and two one way clutches. To minimize fuel consumption, the torque converter clutch is applied by the PCM, depending on throttle position and vehicle speed. These units are currently found in several Mitsubishi models, some Hyundai models and some Kia models, as shown in Figure 1 and 2. The 2007 and later Hyundai models and the 2006 and later Kia models have an added line pressure control solenoid, along with a revised shift solenoid application. Learn More
  5. ATSG Acura Legend 4 Speed G4

    Acura Legend 4 Speed G4

    $8.00
    The Legend transmission is a hydraulic controlled 4 speed front wheel drive transaxle with one reverse speed and a converter clutch. The teardown - assembly and troubleshooting is covered in this manual. Learn More
  6. ATSG Mercedes 722.3 - 722.4 mini CD

    Mercedes 722.3 - 722.4 mini CD

    $30.00
    Mercedes 772.3/722.4 Transmission found in 1980 and up with 6 bolt pan. Covers assembly, dis-assembly, diagnosis, and troubleshooting On mini CD. Learn More
  7. 4R100 Update Handbook Mini CD

    4R100 Update Handbook Mini CD

    $30.00
    Update Handbook for the Ford 4R100 Transmission. Covers all changes that have occured from 1998-UP, parts affected by the changes, interchangability, and part numbers. A must for 4R100 rebuilders on mini CD. Learn More
  8. 6T30-40-45-50_DL

    6T30-40-45-50_DL

    $40.00
    The Hydra-matic 6T30/40/45/50 (6 Speed) is a fully automatic, six speed, front wheel drive, electronically controlled transmission that features clutch to clutch shifting. It is also all-wheel drive capable. It was first introduced in the 2007 Chevy Captiva followed by the Malibu in 2008 and quicky spread to the compact, mid-size, small crossover vehicle line, as shown in Figure 1. The 6T40 is also found in hybrid applications. At the start of production for the 2012 model year Generation 2 was introduced which is currently used in all platforms using the 6T family of transmissions. This series of transmissions is also known as the GF6. It consists primarily of a four element torque converter, three planetary gear sets, five clutch packs, one mechanical one-way clutch and a hydraulic pressurization and control system. Three planetary gear sets provide the six forward gear ratios and reverse. Changing gear ratios is fully automatic and is accomplished through the use of a Transmission Control Module (TCM), that is located within the transmission. The TCM receives and monitors various electronic sensor inputs, and uses this information to shift the transmission at the optimum time. The TCM commands shift solenoids and Clutch Pressure Control (CPC) solenoids within the transmission to control shift timing. The TCM controls shift feel through the CPC solenoids. The TCM also controls the apply and release of the torque converter clutch which allows the engine to deliver the maximum fuel efficiency without sacrificing vehicle performance. This manual contains the procedures necessary to diagnose, overhaul and/or repair the 6T30/40/45/50 (6 Speed) GEN 1 and GEN 2 transmissions from General Motors and is for use by professional technicians. Learn More
  9. ATSG JATCO JF011E_DL

    JATCO JF011E_DL

    $30.00
    Dodge, Jeep, Mitsubishi and Nissan all use a similar continuously variable transmission (CVT) for their 4 cylinder applications. Built by JATCO, the JF011E is the CVT2 in Dodge and Jeep vehicles. The F1CJA (2WD)/W1CJA (4WD) for in Mitsubishi and the RE0F10A in Nissan. This style CVT utilizes a torque converter with its intent to provide an optimal driving force that is responsive to throttle opening providing smooth uninterrupted ratio changes eliminating shift shock. Most applications will provide a manual shift mode function for both smooth driving without shift shock, and enjoyable driving with manual ratio selection. Learn More
  10. ATSG 6R60/75/80_DL

    6R60/75/80_DL

    $30.00
    The 6R60/75/80 is a ZF6HP style transmission specifically fitted for Ford. This transmission can be found in the 2005 Navigator, 2006 Explorer and Mountaineer, 2007 Expedition, 2008 F150 and 2010 Mustang. In 2010, with the introduction of the 6R80 model transmission, changes were made and a low one-way clutch OWC was added to the transmission. Although there are differences specifically suited for Ford, this manual will serve nicely when rebuilding a ZF6HP transmission. Learn More
  11. ATSG ZF6HP21-28 2nd Generation Tech Guide

    ZF6HP21-28 2nd Generation Tech Guide DL

    $35.00
    The BMW ZF6HP21/28/34 and AUDI 6HP28 (2006 &up) transmission is based on the ZF6HP26 that has been in existence since 2002. These transmissions are often referred to as the “2nd Generation” and are used in low and high torque capacity vehicle applications. This Transmission features a Torque Converter with Lock-up Clutch, 3 driving clutches referred to as clutch A, B and E, 2 brake clutches referred to as clutch C and D, a Lepelletier Planetary Gear Train, and internal Transmission Control module referred to as a Mechatronic Module. Mechanically, the six forward speeds and reverse are accomplished through the use of what is known as a Lepelletier planetary gear train, 3 driving clutches and 2 holding brakes as seen in the application chart displayed in Figure 1. Electrically and Hydraulically, this gear box is controlled by what is known as "The Mechatronic Module." This is a combination of a transmission control module and valve body configured as one unit. In other words, the computer for the transmission is mounted onto the valve body and is submerged in transmission fluid. As a result of this Mechatronic Module technology, the pass through case connector from the module to the vehicle harness will basically contain power, ground and CAN Bus network wiring, as well as inputs from the “Tiptronic” Shifter. The Mechatronic Module controls shift timing and shift feel based on inputs from the Engine Control Module, ABS, and the Driver Information Module via the CAN. Shift strategy is controlled by the Mechatronic Module based on shifter input and engine load information received through the CAN bus. The following pages provide information on the valve body breakdown including check ball function and valve function for this family of transmissions. Note: the following information is based on an AUDI 6HP28 valve body that has a manual valve. Some BMW have “E” shift which does not incorporate a manual valve, which changes the valve body configuration. Learn More
  12. ATSG Sprint Suzuki MX17 DL

    Sprint Suzuki MX17 DL

    $30.00
    The Sprint Suzuki 3 Speed automatic transaxle is electrically controled, fully automatic transmission, it utilized a regular non lock-up hydrulic torque converter, two planetary gear set, two multidisk clutch packs in drums, one multidisk clutch in the case and a one way clutch assembly. We have imcluded the latest information on the Geo Metro full electric control for this transmission on the final pages of this manual. Learn More
  13. ATSG 200-4R Mini CD

    200-4R Mini CD

    $30.00
    On Mini CD GM THM 200-4R Transmission FOUND IN MANY 1980 TO 1989 GM domestic vehicles. Covers transaxle assembly, dis-assembly, diagnosis, and troubleshooting. Learn More
  14. ATSG 350C Mini CD

    350C Mini CD

    $30.00

    GM THM 350 Transmission used in many 1969 to 1985 GM domestic vehicles. The ATSG 350 Mini CD covers assembly, dis-assembly, diagnosis, and troubleshooting.

    Learn More
  15. 700-R4  (1982-1986) CD

    700-R4 (1982-1986) CD

    $30.00

    GM THM 700-R4 Transmission (1982 to 1986) found in many domestic vehicles. This ATSG Mini-CD covers assembly, dis-assembly, diagnosis, and troubleshooting. 

    Note: There have been many engineering changes in this transmission since its introduction. ATSG also has available an "Update Handbook"  which includes the many changes and is required along with this manual for a proper overhaul or repair

    Learn More
  16. ATSG 4T40E Mini Cd

    4T40E Mini Cd

    $30.00
    GM 4T40-E Transaxle found in 1995 1/2 to 1996 Chevy Cavalier and Pontiac Sunfire. Covers assembly, dis-assembly, diagnosis, troubleshooting, and electronic controls & operation. Learn More
  17. ATSG JEEP AW-4 MINI CD

    JEEP AW-4 MINI CD

    $30.00
    Jeep AW-4 Transmission found in Jeep Cherokee, Grand Cherokee, and Wagoneer. Covers assembly, dis-assembly, diagnosis, troubleshooting, and electronic controls and operation on Mini CD Learn More
  18. C6 Mini CD

    C6 Mini CD

    $30.00
    C6 Trnasmission found in many Ford domestic vehicles 1966 to 1991. Covers transmission assembly, dis-assembly, diagnosis, and troubleshooting. Learn More
  19. AOD Mini CD

    AOD Mini CD

    $30.00

    AOD Transmission found in many Ford domestic vehicles 1980 to 1991. Covers transmission assembly, dis-assembly, diagnosis, and troubleshooting Mini CD. Learn More
  20. A4LD MINI CD

    A4LD MINI CD

    $30.00
    Ford A4LD Transmission foundin the 1985 to 1995 Aerostar, Ranger, Mustang, Bronco II, and Explorer. Covers transmission assembly, dis-assembly, diagnosis, and troubleshooting.

    Note: There have been many engineering changes in this transmission since its introduction. ATSG also has available an "Update Handbook" which includes the many changes and is required along with this manual for a proper overhaul or repair. Learn More
  21. F4EAT mini CD

    F4EAT mini CD

    $30.00

    Ford F4EAT F4A-EL Transaxle found in 1991 and up Ford Escort. Covers assembly, dis-assembly, diagnosis, and troubleshooting on mini CD Learn More
  22. Freewheel Book Mini CD

    Freewheel Book Mini CD

    $30.00
    Sprag\Roller clutch rotations for most import and domestic vehicles Mini CD. Learn More
  23. ATSG NPR-FUSO-UD CODE BOOK DOWNLOAD

    NPR-FUSO-UD CODE BOOK DOWNLOAD

    $30.00
    This Medium Duty Truck Diagnostic Code Manual has been produced in order to help the diagnostic technician retrieve diagnostic trouble codes from tiltcab trucks such as the Isuzu NPR, Chevrolet Forward, GMC Tiltmaster, Mitsubishi Fuso, Nissan UD and various Hino models. This manual also contains the code retrieval manual process for the Ford and International LCF Series trucks equipped with the 5R110W transmission. These trucks can be equipped with various transmissions such as the JR403E Electromatic, the Aisin Seiki 450-43LE or the Aisin 6 speed transmission. There is also a reference to the Mitsubishi Fuso manufactured Sterling trucks. Since most shops do not have a dedicated scan tool to retrieve codes, this manual contains the manual code retrieval process for the above mentioned vehicles as well as code definitions. It also contains the relearn procedures that are necessary for proper transmission operation. Learn More

Items 51 to 73 of 73 total

per page
Page:
  1. 1
  2. 2

List  Grid 

Set Descending Direction